Powered Pedestrian 4m Lifting Battery Full Electric Pallet Stacker
Keyword:Electric Pallet Stackers Time:2019-10-27 22:56:30
Cautions for Safety Operation of Electric pallet stacker
There are many precautions for safe operation of electric pallet stacker. Here are some suggestions from the company's technical department, hoping to help users. For example:
1. Operators of electric pallet stackers are prohibited from driving after drinking, overweight, super-high and speeding, and from braking or turning sharply. It is forbidden for stacking trucks to enter places where solvents and flammable gases are stored.
2. Safety devices of electric pallet stackers must be complete and intact, each component is sensitive and effective, and the technical performance is good. It is strictly forbidden to drive with illness in pallet stackers.
3. Maintain the standard driving state of electric pallet stacker, when the fork is off the ground, the fork is 10-20 centimeters off the ground. When the electric pallet stacker stops, it falls to the ground left or right and drives on the poor road, its weight should be reduced appropriately, and the driving speed of the electric pallet stacker should be reduced.
4. When the electric pallet stacker runs out of control, the total power supply will be disconnected in time.
5. In the use of electric pallet stacker, special attention should be paid to the timely charging of batteries and the correct maintenance of batteries. When charging the batteries, we should pay attention to the methods. We should not only make the batteries fully charged, but also not cause the excessive charging of the batteries.
6. In the operation of electric pallet stacker, the long-distance acceleration should be used as little as possible. When the pallet stacker starts and the speed increases, the acceleration pedal should be stabilized. If the road condition is good, the pallet stacker will continue to accelerate. When the pallet stacker needs to decelerate, relax the acceleration pedal and gently pedal the brake pedal, so that the energy of deceleration can be fully utilized. If the pallet stacker has regenerative braking function, the kinetic energy of deceleration can be recovered. When the vehicle goes down the ramp, don't disconnect the electric circuit of the driving motor of the pallet stacker, gently press the brake pedal, so that the pallet stacker can run in the regenerative braking state, make use of the kinetic energy of the vehicle going down, and reduce the energy consumption of the storage battery.
7. In the operation of electric pallet stacker, do not mistake the direction switch of "forward and backward" as the steering switch. Do not pedal the brake pedal directly to the bottom unless an emergency deceleration is required. In the process of vehicle operation, when the battery power is insufficient (which can be obtained by electric meter, power loss indicator lamp and other alarm devices), the battery should be charged as soon as possible to prevent excessive discharge of the battery.
8. In the operation of electric pallet stacker, do not always take emergency braking during high-speed driving; otherwise, it will cause huge friction to the brake assembly and driving wheel, shorten the service life of the brake assembly and driving wheel, and even damage the brake assembly and driving wheel.
- No information
-
1. Design objective of electronic crane scale network management. (1) Adopt advanced distributed data processing techno…
-
Electronic crane scale bearing platform installation to focus Electronic crane scale can be installed generally on the li…